Rick's Free Auto Repair Advice » Acadia

Performance Chip? GM Revokes Warranty on Chipped Vehicles

Rick — Fri, 18 Dec 2009 23:16:46 +0000

GM issued a technical service bulleting (TSB) #09-06-04—026 regarding revocation of warranty coverage on any GM vehicle in which the factory calibrations (software) has been removed or altered. The TSB applies to ALL GM gasoline passenger cars and trucks from 2006- present.

It’s important to note that GM is seeing enough damaged engines and transmissions to make this announcement. Here’s a direct quote from the TSB:

“When alteration to the GM-released engine or transmission control calibrations occurs, it subjects powertrain and driveline components (engine , transmission, transfer case, driveshaft and rear axle) to stresses that were not tested by General Motors. It is because of these unknown stresses, and the potential to alter reliability, durability and emissions performance, that GM has adopted a policy to cancel any remaining warranty coverage to the powertrain and driveline components whenever the presence of a non-GM (aftermarket) calibration is confirmed - even if the non-GM control module calibration is subsequently removed.”

The TSB goes on to instruct the dealers on how to determine if the factory calibrations have been altered or removed. So don't think you change restore the factory programming and tear into the dealer when they refuse to cover your warranty claim. They CAN tell what you've done.

So, if you’re planning on “chipping” your vehicle (which I do NOT recommend), be aware that you’re on your own and that the likelihood of damage to the engine and transmission increases dramatically.

Also, remember this: engine design is always a compromise between power, responsiveness, emissions, and fuel economy. You cannot change one variable without changing all the others. So, while chipping may increase power in one range of operation, you will pay for it in other areas. There’s no free lunch, despite what the chipmakers want you to believe.

For more information on this repair or any others for your vehicle, buy an online subscription to either Alldatadiy.com or eautorepair.net. Click on this link to compare the two services: Compare Alldata and Eautorepair.

If you just need information for a single repair and want to save money,eautorepair offers a lower price 1-week subscription for only $11.99. Or, if you'll be working on this vehicle in the future, you can buy a 1-year subscription (Alldatadiy.com for $26.99, or eautorepair.net $29.99)

Alldatadiy.com

eautorepair.net

Both Alldata and Eautorepair offer professional grade shop manuals at a price you can afford. Check them out!.

Hover your mouse over the REPAIR ARTICLES tab at the top of the page. The click on DIAGNOSTICS to search by SYMPTOM, TROUBLE CODE, or read TECH TIPS on how to diagnose a problem

Click on MAKE an MODEL to see all the articles I've written for your vehicle
Click on REPAIR TOPICS to read individual articles written for specific automotive systems

If you've had your car scanned and know the trouble code go to TROUBLE CODES

Here are some quick links to speed up your research

Click on the link below for speedy navigation:

ABS issues, how to bleed ABS brakes

Airbag issues or SRS light on

Alternator issues or how to test

Belt diagram or serpentine belt issues

Blower motor

Blower motor resistor

Brakes, brake issues, what kind of brake parts to buy, ABS issues

Car Alarms or Antitheft systems

Cooling system, Water pump, What type of coolant to use

Engine flush

Firing order, cylinder layout, finding #1 cylinder

MAF or MAP sensor

Oxygen sensors, How they work, How to change, How to test

PassLock or Passkey

Thermostat issues

Transmission flush

Serpentine belt diagrams

Window issues, power window motor, replace window regulator, glass adhesive

Headlights flicker on vehicle with daytime running lights

Rick — Sun, 06 Dec 2009 18:02:10 +0000

Every manufacturer has their share of problems with daytime running lights. Basically the system senses that the vehicle is running and the headlight switch is off. Programmed conclusion? Must be daylight, otherwise the driver would turn on the headlights. Other systems have light sensors. The Chrysler Daytime Running Light system gets screwed up by corrosion in the intelligent power module. Some GM vehicles fail due to a cracked Daytime Running Light resistor (computer provides power to the headlights, but runs it through a resistor to cut down on the headlamp brightness). Still another GM system runs the headlight commands through Daytime Running Lamp Module located behind the left side of the instrument panel. This module contains a diode that has a high failure rate. The module sends a command to the Daytime Running Lamps Relay located in the convenience center (firewall passenger side).

If you have the latter system, remove the relay and insert a jumper wire across the power terminals. See Relay Layout. If that fixes the problem, replace the relay. If it doesn’t, replace the Daytime Running Lamp Module.

Alldatadiy.com

eautorepair.net

Both Alldata and Eautorepair offer professional grade shop manuals at a price you can afford. Check them out!.

Hover your mouse over the REPAIR ARTICLES tab at the top of the page. The click on DIAGNOSTICS to search by SYMPTOM, TROUBLE CODE, or read TECH TIPS on how to diagnose a problem

Click on MAKE an MODEL to see all the articles I've written for your vehicle
Click on REPAIR TOPICS to read individual articles written for specific automotive systems

If you've had your car scanned and know the trouble code go to TROUBLE CODES

Here are some quick links to speed up your research

Click on the link below for speedy navigation:

ABS issues, how to bleed ABS brakes

Airbag issues or SRS light on

Alternator issues or how to test

Belt diagram or serpentine belt issues

Blower motor

Blower motor resistor

Brakes, brake issues, what kind of brake parts to buy, ABS issues

Car Alarms or Antitheft systems

Cooling system, Water pump, What type of coolant to use

Engine flush

Firing order, cylinder layout, finding #1 cylinder

MAF or MAP sensor

Oxygen sensors, How they work, How to change, How to test

PassLock or Passkey

Thermostat issues

Transmission flush

Serpentine belt diagrams

Window issues, power window motor, replace window regulator, glass adhesive

B1000, Airbag light on GM vehicles

Rick — Sat, 17 Oct 2009 04:23:08 +0000

GM has issued a TSB #08-09-004 to correct the false illumination of the airbag light and a corresponding B1000 trouble code. The TSB applies to 2008 Buick Enclave, 2005-08 Cadillac SRX, 2005-08 Chevrolet Equinox, 2007-08 GMC Acadia, 2006-08 Pontiac Torrent,
2007-08 Saturn OUTLOOK, and 2007-08 Suzuki XL-7.

These vehicles come equipped with a Passenger Presence System (PPS) to detect if a passenger is in the vehicle. The system communicates with the ECU and turns the passenger side airbag(s) on or off depending on passenger presences. This TSB requires a software update to correct the false illumination of the SRS light.

Alldatadiy.com

eautorepair.net

Both Alldata and Eautorepair offer professional grade shop manuals at a price you can afford. Check them out!.

Hover your mouse over the REPAIR ARTICLES tab at the top of the page. The click on DIAGNOSTICS to search by SYMPTOM, TROUBLE CODE, or read TECH TIPS on how to diagnose a problem

Click on MAKE an MODEL to see all the articles I've written for your vehicle
Click on REPAIR TOPICS to read individual articles written for specific automotive systems

If you've had your car scanned and know the trouble code go to TROUBLE CODES

Here are some quick links to speed up your research

Click on the link below for speedy navigation:

ABS issues, how to bleed ABS brakes

Airbag issues or SRS light on

Alternator issues or how to test

Belt diagram or serpentine belt issues

Blower motor

Blower motor resistor

Brakes, brake issues, what kind of brake parts to buy, ABS issues

Car Alarms or Antitheft systems

Cooling system, Water pump, What type of coolant to use